處理量30-60噸/小時沙金巖金混合選金處理方案設備清單

設備簡介

本套選金設備為固定式滾筒篩+離心機組合式破碎選金設備，處理量為每小時30-60噸，是我公司根據用戶需求獨立研發制作而成。本套設備運行穩定、故障率低，是當今主流的選金設備，深受國內外用戶的歡迎，其優勢如下：

1、滾筒篩供水系統采用中央供水+兩側供水，中央供水系統負責沖洗滾筒篩內物料，兩側供水系統負責沖洗外部細篩網，防止堵料。

2、本套設備技術成熟，故障率低，保養、維護簡單方便。

3、采用一臺1200#臥式全自動連續排礦離心機，PLC電腦全自動控制無需地面硬化與尋找水平，處理量大，操作簡單方便。

4、采用2臺振動溜槽進行收尾，防止收金草板結、處理量大。

Brief Introduction

This set of gold machine including reamers trommel screen,centrifuge and crushing gold equipment, the capacity of 30-60 t/h, which is our company according to user’s requirements design&manufactured. This set of equipment with easy operation, low failure rate, is the favourite in the market.The advantage as belows:

1.Central water supply system of Reamers&Trommel Screen Separator is on central and trommel’s both sides.The central is used for material washing, both sides is responsible for washing the mesh to prevent clogging.

2.As the technology is mature, machine with lower failure rate, simple operation and convenient maintenance

3.1200# horizontal automatic discharge with no break centrifuge, PLC control without need of seeking balance on ground, simple and convenient operation

4.The 2sets gold shaking sluice with high capacity can prevent the gold grass to be hardening

流程概述

原料通過工程機械送入進料斗，然后通過振動給料機均勻進入一臺鄂式破碎機內進行破碎，破碎后的物料通過一臺上料輸送機進入多鉸刀鉸洗筒內進行鉸泥沖洗，然后進入滾筒篩內進行篩選分級為大于4MM物料與小于4MM物料兩種規格。小于4MM的物料通過滑槽及管道進入盛料箱中；大于4MM的物料進入兩臺巖金礦專用制沙機內進行破碎制沙后進入盛料箱內。

盛料箱內的物料通過沙泵打入離心機內部進行精選，精料通過精料管道排出；廢料排入兩臺振動溜槽進行收尾后，廢料排入廢料池中。

Technological Process

The raw material getting into the hopper by excavator or other, then through the shaking feeder getting into jaw-type crusher to be crushed,the mixture through conveyor into reamers and trommel screen gold separating machine to be separated into 2 sizes,≧4mm≤4mm.The samll size≤4mm getting into mineral box though mineral separating device;the big size≧4mm getting into Sandmaking machine specialized for rockmine to be crushed then into mineral box.

Mineral in mineral box then getting into 100#centrifuge by sand pump to be separating,concentrate get from concentrate discharging port,scrap material into 2sets of gold shaking sluice for further separation,finally the scrap into waste pool.

技術參數

Technological parameter